• Antioxidant active packaging systems to extend the shelf life of sliced cooked ham

      Pateiro, Mirian; Domínguez, Rubén; Bermúdez, Roberto; Munekata, Paulo E.S.; Zhang, Wangang; Gagaoua, Mohammed; Lorenzo, José M.; INIA-MINECO; Axencia Galega de Innovación; CYTED; et al. (Elsevier BV, 2019-11)
      The effectiveness of active packaging systems with green tea extract and oregano essential oil was checked for their use in sliced cooked ham. Three packaging systems were evaluated: i) control group without active film, ii) ATGT packed with active film of green tea extract (1%) and iii) ATRX with a mixture of green tea extract and oregano essential oil (1%). The evolution of microbiological, physicochemical (pH, aw, colour and lipid oxidation) and sensory attributes were analysed after 0, 7, 14 and 21 days of refrigerated storage. Microbial populations were below the limits established by the European Regulations (106 UFC/g). The samples packed with ATGT showed the better antimicrobial activity against total viable counts (TVC) and lactic acid bacteria (BAL), while lower counts of Brochothrix thermosphacta was observed in ATRX film (1.48 vs. 1.78 and 2.59 UFC/g for ATRX vs. ATGT and CON, respectively). Regarding colour, low differences were found between the samples packaged with active and control films. Unlike L*, a* and b* parameters showed a progressive diminution throughout the storage in all batches, being the films that contained green tea (ATGT) were the ones that showed the less discolouration at the end of storage (8.86 vs. 8.63 and 7.50 for ATGT vs. CON and ATRX, respectively). The low fat content of this type of product and the use of anaerobic atmosphere for the packaging of cooked ham did not allow to show an antioxidant effect on lipid oxidation (values below 0.15 mg MDA/kg). Finally, the use of ATGT and ATRX did not suppose a modification of the sensorial attributes of the product, being acceptance scores under the acceptance limit during the whole display.
    • Inclusion of Healthy Oils for Improving the Nutritional Characteristics of Dry-Fermented Deer Sausage

      Vargas-Ramella, Márcio; Munekata, Paulo E. S.; Gagaoua, Mohammed; Franco, Daniel; Campagnol, Paulo C. B.; Pateiro, Mirian; Barretto, Andrea Carla da Silva; Domínguez, Rubén; Lorenzo, José M.; CYTED; et al. (MDPI AG, 2020-10-18)
      The influence of partial replacement of animal fat by healthy oils on composition, physicochemical, volatile, and sensory properties of dry-fermented deer sausage was evaluated. Four different batches were manufactured: the control was formulated with animal fat (18.2%), while in the reformulated batches the 50% of animal fat was substituted by olive, canola, and soy oil emulsions immobilized in Prosella gel. The reformulation resulted in a decrease of moisture and fat contents and an increase of protein and ash amount. Moreover, reformulated sausages were harder, darker, and had higher pH values. This fact is related to the lower moisture content in these samples. As expected, the fatty acid composition was changed by the reformulation. The use of soy and canola oils increased polyunsaturated fatty acids and omega-3 content and decreased n-6/n-3 ratio and saturated fatty acids. Thus, the use of these two oils presented the best nutritional benefits. The changes observed in the fatty acids reflected the fatty acid composition of the oils employed in the emulsions. Regarding volatile compounds (VOC), the replacement of animal fat by healthy emulsion gels increased the content of both total VOC and most of individual VOC. However, the lipid-derived VOC did not show this trend. Generally speaking, the control samples presented similar or higher VOC derived from lipid oxidation processes, which could be related to the natural antioxidant compounds present in the vegetable oils. Finally, all reformulated sausages presented higher consumer acceptability than control samples. In fact, the sausage reformulated with soy oil emulsion gel was the most preferred. Thus, as a general conclusion, the reformulation of deer sausages with soy emulsion gel improves both composition and sensory quality of the final product, which could be an excellent strategy to the elaboration of healthy fermented sausages.
    • Seaweeds as promising resource of bioactive compounds: Overview of novel extraction strategies and design of tailored meat products

      Gullón, Beatriz; GAGAOUA, Mohammed; Barba, Francisco J.; Gullón, Patricia; Zhang, Wangang; Lorenzo, José M.; Axencia Galega de Innovación; CYTED; Spanish Ministry of Economy and Competitiveness; Generalitat Valenciana; et al. (Elsevier BV, 2020-06)
      Background Meat and meat products have been recently perceived by consumers as unhealthy foods. To avoid this drawback, the reformulation is a feasible approach that allows obtaining custom meat-based products that incorporate compounds with certain beneficial properties for health and remove other attributes considered negative. In this framework, the edible seaweeds have been proposed to offer interesting possibilities in the meat sector to develop functional foods as they are an excellent natural source of nutrients and biocompounds with myriad functionalities. Scope and approach This review collects aspects related to the recent technologies employed to obtain and isolate biocompounds from seaweeds. The use of whole seaweeds and their bioactive extracts to develop meat foods that confer them health properties while simultaneously reducing components considered unhealthy in meat are reviewed. Furthermore, the prevention of oxidation events was also described. Key findings and conclusions Several studies have demonstrated that the incorporation of whole seaweeds and their bioactives to reformulate meat products is an excellent approach to improve certain nutritional aspects considered “bad”. However, there are still some challenges regarding the organoleptic and sensory properties of the resulting products that affect the consumer acceptability. In conclusion, more research is necessary to overcome these gaps allowing put in the market seaweeds -based meat products.