Browsing Food Programme by Author "Paludetti, L.F."
The effect of different precooling rates and cold storage on milk microbiological quality and compositionPaludetti, L.F.; Kelly, Alan L.; O'Brien, Bernadette; Jordan, Kieran; Gleeson, David E (Elsevier, 2018-01-10)The objective of this study was to measure the effect of different milk cooling rates, before entering the bulk tank, on the microbiological load and composition of the milk, as well as on energy usage. Three milk precooling treatments were applied before milk entered 3 identical bulk milk tanks: no plate cooler (NP), single-stage plate cooler (SP), and double-stage plate cooler (DP). These precooling treatments cooled the milk to 32.0 ± 1.4°C, 17.0 ± 2.8°C, and 6.0 ± 1.1°C, respectively. Milk was added to the bulk tank twice daily for 72 h, and the tank refrigeration temperature was set at 3°C. The blend temperature within each bulk tank was reduced after each milking event as the volume of milk at 3°C increased simultaneously. The bacterial counts of the milk volumes precooled at different rates did not differ significantly at 0 h of storage or at 24-h intervals thereafter. After 72 h of storage, the total bacterial count of the NP milk was 3.90 ± 0.09 log10 cfu/mL, whereas that of the precooled milk volumes were 3.77 ± 0.09 (SP) and 3.71 ± 0.09 (DP) log10 cfu/mL. The constant storage temperature (3°C) over 72 h helped to reduce bacterial growth rates in milk; consequently, milk composition was not affected and minimal, if any, proteolysis occurred. The DP treatment had the highest energy consumption (17.6 ± 0.5 Wh/L), followed by the NP (16.8 ± 2.7 Wh/L) and SP (10.6 ± 1.3 Wh/L) treatments. This study suggests that bacterial count and composition of milk are minimally affected when milk is stored at 3°C for 72 h, regardless of whether the milk is precooled; however, milk entering the tank should have good initial microbiological quality. Considering the numerical differences between bacterial counts, however, the use of the SP or DP precooling systems is recommended to maintain low levels of bacterial counts and reduce energy consumption.
Evaluating the effect of storage conditions on milk microbiological quality and compositionPaludetti, L.F.; Jordan, Kieran; Kelly, Alan L.; Gleeson, David E (Teagasc (Agriculture and Food Development Authority), Ireland, 2018-07-19)In this study, the effect of storage temperature (2 or 4°C) on the composition of milk and microbiological load was investigated over 96 h. Milk samples were collected from farm bulk milk tanks after one complete milking and stored at 2 or 4°C over 96 h. Total bacterial count (TBC), psychrotrophic bacterial count (PBC) and proteolytic bacterial count (PROT) were affected by storage time and temperature and varied significantly between farms (P < 0.05). The levels of TBC, PBC and PROT bacterial count increased from 4.37 to 6.15 log cfu/mL, 4.34 to 6.44 log cfu/mL and 3.72 to 4.81 log cfu/mL, respectively, when the milk was stored for 96 h at 2°C. The milk samples stored at 4°C had higher increases in these bacterial counts after 72 h in comparison to milk samples stored at 2°C. The casein fraction content was lower in milk samples stored at 4°C, which could be due to high levels of PROT bacteria or enzyme activity in these samples. Milk stored for 96 h at 2°C has less impact on composition or processability parameters compared to milk stored at 4°C.